Cub Cadet 641 Betreibershandbuch

6x4 Utility VehicleModel 641 Operator’s ManualPRINTED IN U.S.A.FORM NO. 769-00688D.fm(1/05)IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLYWar

10Figure 11WARNING: Do not exceed the vehicle’sTotal Load Capacity of 1,400 lb., whichincludes driver, accessories, and cargo. Donot exceed 1000 lbs.

11WARNING: Do not stop or start suddenlywhen going uphill or downhill. Be especiallycautious when changing direction on slopes.Apply brakes when goin

12WARNING: A loaded cargo box can be veryheavy. Do not attempt to dump a loadedcargo box unless vehicle is equipped with anelectric lift option. IMP

13Engine Read the Engine operator’s manual for any service or maintenance information pertaining to the engine. Filling Fuel Tank• Stop the vehicle on

14Replacing HeadlightsHeadlightsThe headlights are held in place by a rubber seal around the perimeter of the headlight which creates a snug fit onto

15NOTE: Drive chain is set taught at the factory, so it willnot reach normal stretch limits until vehicle hasexperienced reasonable hours of operation

16• Park vehicle on level surface and apply parking brake.• Raise and secure cargo box, if manual lift.• Rotate and inspect belt for wear or damage.•

17Adjusting Throttle PedalThe throttle pedal assembly can be adjusted for comfort slightly higher or lower by lining up the holes of the lower pedal a

18SECTION 5: SERVICE CHARTSECTION 6: ACCESSORIESNOTE: Some of these accessories may come alreadyequipped on your vehicle. If they are not equipped,

19SECTION 7: SPECIFICATIONSEngine and ElectricalMake KohlerHP 20 HPType 4-Cycle GasCylinders 2Valves Overhead Displacement 38 cu. in. (624cc)Maximum

2TABLE OF CONTENTSFINDING MODEL NUMBERThis Operator’s Manual is an important part of your new utility vehicle. It will help you assemble, prepare and

20SECTION 8: TROUBLESHOOTINGTrouble Possible Cause(s)Engine loses power Engine overheatingToo much oil in engineFaulty spark plugFuel supply being re

21NOTES

22NOTES

23CUB CADET CORPORATIONMANUFACTURER’S ONE YEAR LIMITED WARRANTY(COMMERCIAL USE)The limited warranty set forth below is given by CUB CADETLLC (“CUB CAD

MANUFACTURER’S LIMITED WARRANTY FOR:The limited warranty set forth below is given by Cub Cadet LLC with respect to new merchandise purchased and used

3SECTION 1: IMPORTANT SAFE OPERATION PRACTICESWARNING: This symbol points out important safety instructions which, if not followed, could endangerthe

425. Do not start or operate vehicle in an inside area, unless it is adequately ventilated. Engine exhaust contains carbon monoxide fumes, which are v

53. When manually raising cargo box, make sure Manual Support Lift Rod is securely locked before leaning under raised cargo box.4. Do not operate vehi

6CARGO BOX LOAD CAPACITY:MAX 1000 Lb.• Spread load evenly. Secure load to prevent movement.• Go slow. Avoid sudden starts and stops which could ca

7SECTION 2: KNOW YOUR UTILITY VEHICLENOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position.Figure

8• To engage the parking brake, push brake pedal down firmly, pull out on the parking brake latch, and release foot from brake pedal. Brake pedal will

9Hour Meter The hour meter is located in the center of the warning light cluster. It reads the elapsed time engine has run.See Figure 6.NOTE: The hou